Generac-power-systems 00862-1 Uživatelský manuál

Manual No. A9-12?OWNER'S MANUALand Installation InstructionsSeries QP55-GAIR-COOLED RECREATIONAL VEHICLE GENERATORSModel No. 00862-1POWER SYSTEMS

ENGINE PROTECTIVE DEVICESAUTOMATIC LOW OIL PRESSURE SHUTDOWNThe engine is equipped with a normally closed (N.C.) oil pressure switch (Figure 4).

SPECIFICATIONSFUEL REQUIREMENTSThis generator is equipped with a gasoline fuel system as standard equipment. Specific installations may pr

MAINTENANCEThis section includes information about simple maintenance which includes the following tasks;• Checking the engine oil level.• Changi

ENGINE AIR CLEANERClean and re-oil the foam pre-cleaner every three months or every 25 hours of operation, whichever occurs first. Servi

BATTERYAll lead-acid storage batteries will discharge when not in use. Inspect the generator battery as follows:Once Weekly: Inspect battery posts

INSTALLATION SAFETY RULESDANGER: For fire safety, installation of a generator into a recreational vehicle must comply strictly with article 551, N

GENERAL INSTALLATION INFORMATIONPURPOSE AND SCOPE OF MANUALThese Installation Instructions have been prepared especially for the purpose of

LOCATION AND SUPPORTGENERATOR LOCATIONThe most desirable location for the generator set is between the vehicle's main frame members

GENERATOR RESTRAINTUse four 3/8"-16 hardened steel bolts (Grade 5) to fasten the generator to the supporting frame or the support

COMPARTMENT SIZEPlan the compartment size carefully. Provide a minimum clearance of 1/2 inch on the front and top, 1 inch on thè

GENERAL SAFETY RULESTHE MANUFACTURER SUGGESTS THAT THESE "RULES” FOR SAFE OPERATION BEA COPIED AND POSTED IN POTENTIAL HAZARD AREAS OF THE RECREA

ACOUSTICSFor additional noise abatement the installer may wish to consider the following:• Using special sound insulating materials.• Construction o

COOLING AND VENTILATING AIRIt is absolutely essential that an adequate flow of air for cooling, ventilating and engine combustion be supplied to the

Figure 25 — Air Inlet Using DuctworkFigure 26 — Air Inlet in Vehicle SkirtCOMPENSATING FOR RESTRICTIONSSuch materials as screening, louvers, or

GASOLINE FUEL SYSTEMInstalling a gasoline fuel system (Figure 27) for recreational vehicle generator sets must comply with applicable codes,

EXHAUST SYSTEMThe generator exhaust system must be safely and properly installed. Only approved mufflers and other exhaust system parts

ELECTRICAL CONNECTIONSBe sure to read “Generator AC Connection System” on Page 14.The following general rules apply to electrical connections

• If you use metallic conduit, vapor seal the end of the conduit where it enters the junction box. Do this because flexible metallic conduit is not v

— 26 —

BATTERY INSTALLATIONRECOMMENDED BAHERYInstall a battery that meets the following requirements:• Battery must be a 12 volt, automotive type storage ba

IDENTIFICATION RECORD AND GENERATOR FEATURESPlease record the following information from the generator DATA DECAI- or information decal.1.Model Number

OPTIONAL ACCESSORIESA plug-in receptacle (Figure 33) is provided on the generator set, above the muffler enclosure. Use this receptacle to connect a

POST INSTALLATION TESTSThe air cooled generator set was factory tested and adjusted using gasoline as a fuel. You should not be requi

INSTALLATION CHECK LISTLOCATION AND SUPPORTELECTRICAL CONNECTIONS___1. The generator is properly located.___2. The generator is properly supported.___

coо"Пm>33mсл>оgsmZСЛOСЛ

TROUBLESHOOTINGPROBLEM POSSIBLE CAUSES REMEDYEngine won't crank. 1.Fuse is blown.1.Replace fuse.2. Loose corroded or detective battery cables.2.T

ELECTRICAL DATADrawing No. A6692 Rev. ALETQENDвсе - BAtTGRY CKARGC RECTirtCRCBl - CIRCUIT BREAXER. 30AСВг - CIRCUIT BREAKER, 20AСВЭ - CIRCUIT

ELECTRICAL DATADrawing No. A6692 Rev. A‘issvia.*’~*<uTt«L COMCCTIOH 9t cSV9€»35 —

EXPLODED VIEW — ENGINE ACCESSORIESDrawing No. kl22>5— 36 —

REPAIR PARTS — ENGINE ACCESSORIESDrawing No. A7235 ITEM PART NO. QTY.DESCRIPTION1A65321MANIFOLD, INTAKE291039 1GASKET. MANIFOLD/HEAD3 51753 1HHCS-M6-1

TABLE OF CONTENTSOPERATING INSTRUCTIONSGENERAL SAFETY RULES...inside coverIDENTIFICATION RECORD AND GENERATOR FEAT

EXPLODED VIEW — SHEET METALDrawing No. A7233COcs— 38 —

REPAIR PARTS — SHEET METALDrawing No. A7233ITEM PART NO.QTY. DESCRIPTION1A43231SCROLL, FLYWHEEL245756 9 SCREW. TAPTITE M6-1.0 x 10 LG3292892.5ft.FOAM

Drawing No. A9650EXPLODED VIEW — BASE AND PULLEYS 40 —

__________________ REPAIR PARTS — BASE AND PULLEYSDrawing No. A9650ITEM PART#. QTY. DESCRIPTION ITEM PART#. QTY. DESCRIPTION1A58551 BASE, MOUNTING 33

EXPLODED VIEW — ALTERNATOR AND CONTROL PANELDrawing No. A9649— 42 —

REPAIR PARTS — ALTERNATOR AND CONTROL PANELDrawing No. A9649ITEM PART#. QTY. DESCRIPTIONITEMPART#. QTY.DESCRIPTION175995 1 LOWER BEARING CARRIER 39 43

EXPLODED VIEW — ENGINE PARTSDrawing No. A7894— 44 —

REPAIR PARTS — GN410 ENGINEDrawing No. A7894ITEM PART#. QTY. DESCRIPTION ITEM PART#.QTY.DESCRIPTION1215331 PISTON RING SET33 A73081GOVERNOR SPOOL2 719

EXPLODED VIEW — ENCLOSUREDrawing No. A9648— 46 —

REPAIR PARTS — ENCLOSUREDrawing No. A9648ITEM PART NO. QTY.DESCRIPTION1A91311 PANEL, TOP COVER2A9127 1 LOUVERED BACK COVER3A91291 PANEL, ENGINE SIDE4

READ THIS MANUAL THOROUGHLYIf you don't understand any portion of this manual, contact Generac for a demonstration of actual start

CALIFORNIA EMISSION CONTROL WARRANTY STATEMENTYOUR WARRANTY RIGHTS AND OBLIGATIONSThe California Air Resources Board (“CARB") and Generac

EMISSION CONTROL SYSTEM WARRANTYEmission Control System Warranty (“ECS Warranty") for 1995 and Later Model Year Utility and Lawn and Garden Equip

Generac’s Three-Year Limited Warranty For Recreationai Vehicie GeneratorsGenerac warrants to the original owner and subsequent purchasers from the dat

GENERATOR FAMILIARIZATIONGENERATOR APPLICABILITYThese generators have been designed and manufactured for supplying electrical power tor r

OPERATING INSTRUCTIONSGENERATOR CONTROL PANELMounted on the generator control panel (Figure 2) are the following features:Figure 2 — Typical Control P

ENGINE EXHAUST GASBefore starting the generator engine, you should be sure there is no way for exhaust gases to enter the vehicle in

AOPERATING PRECAUTIONSNever operate the recreational vehicle generator set while the vehicle is parked over dry leaves, dry grass or any